Home / Business / Boeing declared 737 max 8 ‘not suitable’ for certain airports

Boeing declared 737 max 8 ‘not suitable’ for certain airports

Before last month’s crash of a flight that began in Ethiopia, Boeing Co said in a legal document that large, upgraded 737s “cannot be used at what are referred to as ‘high/hot’ airports.”

At an elevation of 7,657 feet or more than a mile high — Addis Ababa’s Bole International Airport falls into that category. High elevations require longer runways and faster speeds for take-off.

The Ethiopian airport’s altitude hasn’t been cited as a factor in the downing of Flight 302 and likely didn’t cause the crash. But it could have exacerbated the situation because an air-plane’s performance degrades at higher altitudes, said a 737 pilot who flies into high-elevation airports such as Denver and agreed to speak on background since he’s not authorised to talk with the media.

Data released last week from the Ethiopian Airlines flight indicated the pilots didn’t cut the 737 Max 8 air-plane’s speed after take-off when they should have. The preliminary report on the disaster said the plane’s anti-stall system pushed the nose of the plane down less than two minutes into the flight because of a malfunctioning sensor.

The pilots struggled to control the plane as it hurtled toward the ground at 575 miles per hour.

“The faster the airplane is going, the more force of air there is on its wings and control surfaces which requires more force on the pilots’ part to pull the control” column, said Robert Mark, a commercial pilot and senior editor with Flying Magazine.

Boeing cited the performance of the 737 Max 8 in a case brought before the US International Trade Commission in 2017. Boeing charged that unfair competition from Bombardier — which beat out Boeing for a large order from Delta Air Lines — threatened its 737-700 and Max 7, the smallest of its upgraded single-aisle jets. By pointing out the limitations of the Max 8, the plane-maker sought to preserve market share for the 700 and Max 7.

A Boeing spokesman said that Addis Ababa can handle large airplanes because it has long runways.

‘‘Challenging Airports’’

Boeing stated in a brief filed in the trade case that the “737 Max 7 has greater performance capabilities at challenging airports. In particular, the 737 Max 7 can serve certain ‘high/hot’ airports and has a greater range operating out of constrained airfields.”

The brief then cites a number of such airports — the names of which are redacted — that the Max 7 can fly into that “the 8, 9 and 10 cannot.”

“Larger 737 variants cannot be used at what are referred to has ‘high/hot’ airports,” the brief stated. Certain US airports are unsuitable for the Max 8 “due to a combination of short runway lengths, elevation, temperature, humidity and other environmental conditions.”

Aviation consultant Bob Mann said airlines typically use a smaller, earlier version of Boeing’s jet, the 737-700, at higher elevations because that plane usually gets a “better rate of climb” than the Max 8.

Denver and Mexico City

Documents in the trade case referred to at least 16 US airports considered “high and hot” and therefore unsuitable for the Max 8, though the names of those facilities weren’t made public.

Asked during a trade commission hearing to specify which airports, an expert witness for Boeing replied that “sometimes Denver would qualify as that.” The expert, Jerry Nickelsburg, an adjunct economics professor at UCLA, added that “Mexico City certainly qualifies as that.”

Both the Denver and Mexico City airports sit at lower elevations than Addis Ababa and have runways as long or longer than the Ethiopian airfield, where they extend more than 12,000 feet, or 3,700 meters.

Denver’s airport is more than 2,000 feet lower than Addis and has five runways that measure 12,000 feet and one that is 16,000 feet (or 4,800 meters). The airport in Mexico City is 300 feet lower than Addis and has four runways that are 13,000 feet (or about 4,000 meters) and two that are 15,000 feet (or about 4,600 meters). Aeromexico flies the Max 8 as part of its fleet.

Hot airfields such as the Jakarta airport, from where the doomed Lion Air plane took off last October, produce similar air densities as high elevations, requiring faster take-off speeds. Heat, air density and fast speed haven’t been cited as factors in that accident.

‘‘Detective Story’’

The performance of all airplanes deteriorates in high heat or elevation, and all pilots account for that before taking off, said Steve Wallace, former director of the Federal Aviation Administration’s accident investigation branch.

Even airlines operating from Orange County, California, which is nearly at sea level, occasionally have to reduce weight on their planes because of high temperatures, Wallace said.

Altitude and heat may well have played no role in either 737 Max 8 crash, but the wording from Boeing’s 2017 trade case could still be seized upon by plaintiffs lawyers.

“Even if it is BS, plaintiffs’ lawyers will focus on the quote and put that back to the company to explain it,” said long-time aviation attorney Roger Clark, who teaches aviation law as a visiting professor at Rutgers University in New Jersey.

Chicago attorney Thomas Demetrio, who is leading a lawsuit against Boeing for the Lion Air crash, said he wouldn’t include altitude or heat in a complaint unless investigators or one of his experts said those factors were a proximate cause.

All the factors that contributed to the Ethiopian Airlines crash won’t be known until sometime next year when the full investigative report is completed.

“It’s like a detective story right now,” said Mark, the commercial pilot. “And we don’t have all the data.”

Check Also

Zim to be food insecure by September: USAid

MOST of the country’s districts will be food insecure by September due to a poor …

Leave a Reply

Your email address will not be published. Required fields are marked *